2011 BMW X1 problems

• N47D20 143 hp (U0/U1, 2007-2014)

  143 hp · N47D20U0, N47D20U1

  Same timing chain risk as the rest of the range; it is worth verifying the timing history before buying.^[3][4]

  With caution

• N47D20 177-184 hp (O0/O1, 2007-2014)

  177–184 hp · N47D20O0, N47D20O1

  It is the most widely fitted N47D20 version (120d, 320d, 520d) and shares the same rear chain defect documented across the whole family.^[3][4]

  With caution

• N47D20 204-218 hp twin-turbo (2007-2014)

  204–218 hp · N47D20T0, N47S1

  As the most highly stressed N47D20 version, the additional thermal stress does nothing to reduce the known risk of the rear timing chain.^[3][4]

  With caution

Faults that affect 2011 cars

• Critical severityFrequency: Very frequentTimingRear timing chain stretch and breakageYes: the N47 has its timing chain at the rear of the engine, next to the gearbox, and on a very high proportion of units, especially those built between 2007 and 2009, it stretches or breaks prematurely because of an inadequate tensioner, with a risk of destroying the engine.Repair (garage): €1,590–€3,000Appears at around 50,000 km
• Critical severityFrequency: CommonIntakeBroken intake manifold swirl flapsYes: the N47's intake manifold has plastic swirl flaps that, with diesel soot and the passing years, can crack, come loose and be sucked into the cylinder, with a risk of seriously damaging the piston, cylinder head and valves.
• High severityFrequency: CommonTurboTurbo and wastegate valve failureThe N47's turbo does not usually fail from general wear, but because of failure of the wastegate valve, which regulates boost and can seize or lose adjustment, sending fuel consumption soaring; oil leaks from the turbo itself are also common.Repair (garage): €900–€1,800
• Medium severityFrequency: CommonEmissions controlClogged or seized EGR valveYes, as on most diesels of its generation: the N47's EGR valve seizes or clogs with carbon, especially on cars used in town, causing an unstable idle, jerking and loss of power; it is not usually a serious fault if it is cleaned or replaced in time.Repair (garage): €400–€1,500
• Medium severityFrequency: CommonClutchDual-mass flywheel wear (manual gearbox versions)Yes: on manual-gearbox BMW N47s, the dual-mass flywheel can wear, especially after a lot of town mileage or driving in high gears at low revs; the typical symptoms are vibrations, a metallic rattle at idle and jerking when pulling away.Appears at around 150,000 km

• N20B20B 184 hp (135 kW, 2011-2017)

  184 hp · N20B20, N20B20B

  It shares with the rest of the N20 family the risk of wear to the timing chain guides and tensioner on units built before 2015.^[6]

  With caution

• N20B20A 245 hp (180 kW, 2011-2017)

  245 hp · N20B20, N20B20A

  It shares with the rest of the N20 family the risk of wear to the timing chain guides and tensioner on units built before 2015.^[6]

  With caution

Faults that affect 2011 cars

• Critical severityFrequency: CommonTimingTiming chain guide and tensioner wear (2011-2015)Yes: on BMW N20s built mainly between 2011 and 2015, the timing chain guides and tensioner wear out early; if the chain jumps teeth it can put pistons and valves out of sync and cause catastrophic damage. BMW revised the design in 2015, without a formal recall.Appears at around 129,000 km
• Critical severityFrequency: OccasionalCoolingElectric water pump failure (BMW campaign in the US over fire risk)The N20 has an electric water pump whose connector can suffer ingress of blow-by liquid; a short circuit can cause local overheating and, very rarely, a fire. BMW recalled 720,000 vehicles in the US in 2024, not including the European Union or Spain.
• Medium severityFrequency: CommonLubricationOil leaks from the rocker cover gasket and the filter housingYes: with the years and heat cycles, the rocker cover gasket and the oil filter housing or cooler gasket on the N20 start to weep oil; it is not an acute defect but expected wear that is worth watching before the oil level drops too low.
• Medium severityFrequency: OccasionalTurboWastegate noise and plastic charge pipe breakageThe N20's single TwinScroll turbo is not, in itself, a frequent point of failure, but over the years wastegate noise or rattle and a loss of pressure can appear, and the plastic pipe that carries air from the turbo to the intercooler can crack, especially with poor maintenance or on modified engines.
• Medium severityFrequency: OccasionalInjectionHigh-pressure fuel pump (HPFP) failureThe high-pressure pump that feeds the N20's direct injection (High Precision Injection) can fail, especially on high-mileage units, leaving the car with hard starting, jerking or, in the worst case, unable to start.

• N46NB20 150-170 hp, revised ECU (2006-2012)

  150–170 hp · N46NB20

  It shares the risk of chain, Valvetronic and VANOS wear with the rest of the family; as it keeps indirect injection, it does not show the injector and NOx sensor failures specific to the N43.^[7][8][9]

  With caution

Faults that affect 2011 cars

• Critical severityFrequency: CommonTimingWear and breakage of the timing chain guidesYes: both the N43 and the N46 can stretch the timing chain and wear its plastic guides and tensioner. On the N43, English-language Wikipedia documents that a broken guide can release fragments that block the oil strainer and cause serious damage through lack of lubrication.
• Medium severityFrequency: CommonIntakeWear of the Valvetronic and the VANOS solenoid valvesOver the years, the eccentric shaft or the actuator motor of the Valvetronic can wear and cause heavy idle fluctuations; the VANOS solenoid valves also fail over time, with similar symptoms and a loss of power. According to English-language Wikipedia, the 1.6-litre N43B16 does not have Valvetronic.
• Medium severityFrequency: CommonLubricationOil leaks and consumption (rocker cover, vacuum pump and valve stem seals)Over the years, the rocker cover gasket and the brake servo vacuum pump gasket start to seep oil on the N43 and N46; on the N46 there are also the valve stem seals, which can cause more noticeable oil consumption than on the N43.

• N52B30 3.0 (2004-2015)

  215–268 hp · N52B30, N51B30

  Same weak points as the N52B25; units from before the end of 2008 may have noisy hydraulic lifters.^[10][11]

  With caution

Faults that affect 2011 cars

• Medium severityFrequency: CommonCoolingElectric water pump and thermostat failureThe N52's plastic electric water pump cracks or fails sooner than a mechanical one, and the thermostat usually goes with it; it is recommended to replace it as a precaution at around 80,000-100,000 km.Repair (garage): €350–€600Appears at around 80,000 km
• Medium severityFrequency: CommonLubricationOil leak from the oil filter housing gasketThe oil filter housing gasket hardens over time and leaks oil on all N52 engines; the leak can soil the engine and damage nearby parts.
• Low severityFrequency: CommonLubricationValve cover and crankcase ventilation valveThe N52's plastic valve cover cracks with heat cycles and the crankcase ventilation system fails, causing whistling, leaks and oil consumption.Repair (garage): €200–€350

• High severityFrequency: OccasionalGearbox and clutchxDrive transfer case failure on the X1 E84According to the fiches-auto.fr reports, the xDrive transfer case on the X1 E84 appears in 26 cases, with jerking and thumps in the drivetrain between 27,000 and 110,000 km. It is an owner reference, not a fault confirmed by the manufacturer.Appears at around 27,000 km
• Critical severityFrequency: RareSteeringLoss of electric power steering assistance on the BMW X1 E84According to the KBA, as cited by Gebrauchtwagenberater.de, a fault in the electronics of the electric power steering can leave the car without assistance; it affects X1s built up to and including 2012.
• Medium severityFrequency: OccasionalGearbox and clutchPremature wear of the clutch and flywheel on the manual X1According to the reports collected by fiches-auto.fr, the clutch is the most cited point on the manual X1 E84: 48 mentions out of 315 reports, with vibrations, noise in first gear and wear between 32,000 and 95,000 km. There is no known official campaign.Appears at around 32,000 km
• Medium severityFrequency: OccasionalSuspensionNoises and wear in the suspension, bushes and bearings of the X1 E84According to fiches-auto.fr, the suspension, bushes and bearings account for 23 mentions out of 315 reports on the X1 E84: creaks, premature tyre wear and bearing noise from around 170,000 km.
• Medium severityFrequency: OccasionalElectronics and infotainmentFaults in the iDrive, the GPS and the electronic modules of the X1 E84According to fiches-auto.fr, the X1 E84's electronics account for 21 mentions out of 315 reports: an iDrive that freezes, a GPS that fails, warnings on the dashboard and faults caused by water ingress. There is no known official campaign.
• Medium severityFrequency: RareGearbox and clutchDriveshaft flex disc failure on the 2010-2011 X1Gebrauchtwagenberater.de records a campaign for a possible break in the driveshaft's flexible disc on X1 E84s built from December 2010 to June 2011, with a risk of being left stranded.
• Low severityFrequency: RareSteeringCreaking from the steering column cross-joint on the X1 E84Gebrauchtwagenberater.de notes that a defective steering column cross-joint can produce creaks when manoeuvring or with the steering wheel at full lock, mainly on the older X1s.